|
|
|
6kV~35kV
中低压铜芯及铝芯交联聚乙烯绝缘电力电缆（YJV电缆，YJV22电缆，YJLV电缆，YJLV22电缆）
XLPE Insulated Power Cable |
交联聚乙烯绝缘电力电缆是采用化学方法或物理方法,使聚乙烯分子由线型分子结构转变为三维网状结构,由热塑性的聚乙烯变成热固性的交联聚乙烯,从而提高了聚乙烯的耐老化性能、机械性能和耐环境能力，并保持了优良的电气性能。
交联聚乙烯绝缘电力电缆导体的允许长期最高温为90摄氏度，较低绝缘电缆、聚氯乙烯绝缘电缆和聚乙烯绝缘电缆高，且具有重量轻、结构简单、使用方便、耐化学腐蚀和敷设不受落差限制等优点。
26/35KV电力电缆，18/30KV交联电缆，12/20KVYJV电缆，8.7/15KVYJV22电缆线，6/10KV铝芯交联电缆线，3.6/6KVYJLV单芯电缆
中低压交联电缆产品标准 Standard
本产品按GB12706《额定电压35V及以下铜芯、铝芯塑料绝缘电力电缆》标准生产，同时还可根据用户需要按国际电工委员会推荐标准IEC、英国标准、德国标准及美国标准生产。
The product is manufactured according to the
standard of《GB12706 or IEC、BS、DIN and ICEA
upon request.
适用范围 Applications
本产品适用于工频额定电压3.6/6kv～26/35kv输配电线路作配送电能子用。
The product is suitable for use in power
transmission and distribution lines with
rated power frequency voltage
3.6/6kv～26/35kv.
使用特性 Operating characteristics
· 工频额定电压U0/U为3.6/6kv～26/35kv。
Rated power-frepuency voltage U0/U:
3.6/6kv～26/35kv.
· 电缆导体的最高允许工作温度：90℃。
Max.admissible operating temperature of the
conductor:90℃.
· 短路时（最长时间不超过5s）电缆导体的最高温度不超过2500C。
Max. short-circurt temperature of conductor
shall not exceed 2500C.
(5s maximum duration)
· 电缆敷设时环境温度应不低于00C。
The ambient temperature under installation
should not below 00C.
· 电缆弯曲半径：三芯电缆不小于电缆外径15倍；单芯电缆不小于电缆外径20倍。
The bending radius of a single-core cable
should not less than 20 times of the cable
diameter.
The bending radius of a single-core cable
should not less than 15 times of the cable
diameter.
电缆额定电压的选择 Voltage designation
· 电缆的额定电压应适合于电缆系统的运行状况，用U0/U（Um）kv表示。
U0－电缆设计用的导体对地或金属屏蔽之间的额定工频电压；
U－电缆设计用的导体间的额定工频电压；
Um－设备可承受的“最高系统电压”的最大值。
The rated voltage of the cable for a given
applixation shall be suitable for the
operating conditions
in the system in which the cable is used,and
is expressed in the form of U0/U（Um）kv
Where:
U0－The rated power-frequency voltage between
conductors and earth metallic screen ,for
which the cable designed;
U － The rated power-frequency voltage
between conductos, for which the cable
designed;
Um－ The maximum value of the“highest system
voltage”for which the equipment may beused.
· 三相系统用电缆的U0值推荐如下表：
The values of U0 recommened for cable to be
used in three-phase systems are listed
below:
|
|
U kv |
U m kv |
U 0 * kv |
|
A 和 B 类系统
System categories A and B |
C 类系统 Systems
categories C |
|
6 |
7.2 |
3.6 |
6 |
|
10 |
12 |
6 |
8.7 |
|
15 |
17.5 |
8.7 |
12 |
|
20 |
24 |
12 |
18 |
|
30 |
36 |
18 |
－ |
|
35 |
40.5 |
21 |
26 |
|
A类系统──该类系统任何一相导体与地和接地导体接触时，能在1min内与系统分离
B类系统──该类系统仅包括单相接地故障短时运行的条件，接地故障时间应不超过1h,
但在任何情况下，最长不超过8h每年接地故障总持续时间不超过125h；
C类系统──不属于A类、B类的系统。
System category A──This category comprises
those systems in which any phase conductor
that comes in contact with earth or an earth
conductor. is disconnected from the system
within 1 min.
System category B ──This category comprises
those system which,under faultconditions,are
operated,are operated for ashorttimewith one
phase earthed.This period should not exceed
1 h..Fora longer period, not exceeding 8h on
any occasion, can be tolerated.The total
duration of earth faults in any year should
not exceed 125h.
System categeory C──This category comprises
all systems which do not fall into A and B
电缆的型号Type of cable |
|
型号 Type |
名称 Designation |
适用范围
Application |
|
YJV |
铜芯交联聚乙烯绝缘氯乙烯护套电力电缆 Copper
conductor,XLPE insulated and PVC
sheathed power cable |
室内、隧道及电缆沟等场所，不能承受机械外力。单芯电缆不允许敷设在磁性管道中。
For laying indoors 、 intunnel or
cable trench,unable to bear external
mechan-icalforces.Single-core cable
in magnetic duct is not permissible |
|
YJLY |
铝芯交联聚乙烯绝缘乙烯护套电力电缆 Aluminium
conductor, XLPE insulated and PVC
sheathed power cable |
|
YJY |
铜芯交联聚乙烯绝缘氯乙烯护套电力电缆 Copper conductor
,XLPE insulated and PEsheathed power
cable |
|
YJLY |
铝芯交联聚乙烯绝缘氯乙烯护套电力电缆 Alumimium
conductor ,XLPE insulated and
PEsheathed power cable |
|
YJV22 |
铜芯交联聚乙烯绝缘钢带铠装聚氯乙烯护套电力电缆 Copper
conductor ,XLPE insulated, steel
tape armoured and PVC sheathed power
cable |
室内、隧道、电缆沟内，或埋地敷设等，能承受一定机械外力，但不能承受大的拉力。
For laying indoors 、 in tunnel,
cable trench, or direct in
ground,able to bear external
mechanicalforces, but unable to bear
large pulling force 。 |
|
YJLV22 |
铝芯交联聚乙烯绝缘钢带铠装聚氯乙烯护套电力电缆 Aluminium
conductor ,XLPE insulated ,steel
tape armoured and PVC sheathed power
cable |
|
YJV23 |
铜芯交联聚乙烯绝缘钢带铠装聚氯乙烯护套电力电缆 Copper
conductor ,XLPE insulated ,steel
tape armoured and PVC sheathed power
cable |
|
YJLV23 |
铝芯交联聚乙烯绝缘钢带铠装聚氯乙烯护套电力电缆 Aluminium
conductor ,XLPE insulated ,steel
tape armoured and PVC sheathed power
cable |
|
YJV32 |
铜芯交联聚乙烯绝缘细钢丝铠装聚氯乙烯护套电力电缆 Copper
conductor,XLPE insulated,steel wire
armoured and PVC sheathed power
cable |
室内、隧道、电缆沟、竖井或埋地敷设等，能承受机械外力和一定的拉力。
For laying indoors 、 in tunnel,
cable french, well or direct in
ground,able to bear external
mechanical forces, and certain force
。 |
|
YJLV32 |
铝芯交联聚乙烯绝缘细钢丝铠装聚氯乙烯护套电力电缆 Aluminium
conductor ,XLPE insulated, steel
wire armoured and PVC sheathed power
cable |
|
YJV33 |
铜芯交联聚乙烯绝缘细钢丝铠装聚氯乙烯护套电力电缆 Copper
conductor ,XLPE insulated ,steel
wire armoured and PVC sheathed power
cable |
|
YJLV33 |
铝芯交联聚乙烯绝缘钢带铠装聚氯乙烯护套电力电缆 Aluminium
conductor ,XLPE insulated ,steel
wire armoured and PVC sheathed power
cable |
|
|
生产范围Production range of cable |
|
型号 Type |
芯数 Nomber of
cores |
额定电压 Rated
Voltage kV |
|
3.6/6 |
6/6 6/10 |
8.7/10 8.7/15 |
12/20 |
18/20 18/30 |
21/35 |
26/35 |
|
导体标称截面 Nominal
cross-section of conductlr mm2 |
YJV
YJLV
YJY
YJLY |
1 |
25-800 |
25-800 |
25-800 |
35-800 |
50-630 |
50-630 |
50-630 |
|
3 |
25-630 |
25-630 |
25-500 |
35-500 |
50-400 |
50-400 |
50-400 |
YJV22
YJLV22
YJY23
YJLY23 |
1 |
25-800 |
25-800 |
25-800 |
35-800 |
50-630 |
50-630 |
50-630 |
|
3 |
25-630 |
25-630 |
25-500 |
35-500 |
50-400 |
50-400 |
50-400 |
YJV32
YJLV32
YJY33
YJLY33 |
1 |
25-800 |
25-800 |
25-800 |
35-800 |
50-630 |
50-630 |
50-630 |
|
3 |
25-630 |
25-630 |
25-400 |
35-400 |
50-240 |
50-185 |
50-150 |
|
|
